Hello Guest
« previous next »
Pages: [1]   Go Down

Sagging Driver door, any tips on a fix?

  • 6 Replies
  • 1802 Views

0 Members and 6 Guests are viewing this topic.

*

Offline Festiva

  • 92
  • 0
  • I Love ZUKIWORLD!
Sagging Driver door, any tips on a fix?
« on: November 30, 2005, 08:02:12 AM »
Hi there fellas, my drivers door is starting to sag Bad!, is this a common problem on a tracker/sidekick? looks like either the pin might be worn but almost looks like the metal behind the hinge is rusty!,...


Anyone ever have this problem and happen to have any fix tips?
 Thanks!
    Jason
Logged
*

Offline Cwkick

  • 888
  • 0
  • Gender: Male
Re: Sagging Driver door, any tips on a fix?
« Reply #1 on: November 30, 2005, 08:07:56 AM »
It is a common problem.  I had to have a top hinge rewelded once.   :-[

Cwkick
Logged
*

Offline wildgoody

  • *
  • 8134
  • 67
  • Gender: Male
  • Turbocharged 150HP 1.6L 8V 93MPH 1/4 mile
Re: Sagging Driver door, any tips on a fix?
« Reply #2 on: November 30, 2005, 08:11:14 AM »
My top hinge was pulling off the body,
but that's after the door about got pulled
off backwards, I knocked the hinge mount
spot in some and welded the hinge back on
Logged
Real Trucks Are Built, Not Bought,
And Chrome Don't Get Ya Home.  

An armed man is a citizen. An unarmed man is a subject.
*

Offline CBTracker

  • 140
  • 0
  • OH, you think I can't make it through?
Re: Sagging Driver door, any tips on a fix?
« Reply #3 on: December 05, 2005, 10:20:48 AM »
On my tracker I just picked up some door pins from a local parts place and drilled out the old ones, put collars in and popped the new pins in, works great, also some washers btween the hinge and truck/or door work good on other cars, not too sure about the sammie though
Logged
96 Tracker 2dr on 215s, 2inch suslift soft top, GPS Nav, Light bar.
89 Tracker 2dr hardtop, 235s 1inchsus custom body work, push button starter
*

Offline mrfuelish

  • *
  • 2862
  • 13
  • Gender: Male
  • you must have a perception problem.
Re: Sagging Driver door, any tips on a fix?
« Reply #4 on: December 05, 2005, 02:35:27 PM »
The sammies are easy, you just loosen the four bolts and move the door where ya want it and tighten them back up. I found an easy way to loosen them too.  ;D with out messing them up.
Logged
1987,1988,1988,1990 samurai's,  1953 m38a1,  1996 x-90,blue.1996 x-90 red.1994 2 door tracker.   only Dead Fish go with the flow.                No Hairy Nosed Wombats were ran over on the trail today.       My ZUK is Xenophobic.
*

Offline Blasted

  • 63
  • 0
  • Gender: Male
  • Yea.. its a Kick.. Keep dreamin.
Re: Sagging Driver door, any tips on a fix?
« Reply #5 on: December 05, 2005, 08:55:34 PM »
I paid a local body shop to replace mine.. Cut the old soft metal out behind the hinge points and replaced it with thicker guage steel.  Cost me 200 but came with a lifetime warranty. Its a totaly common problem. The dude at the body shop said mine was at least the 12th or so hes worked on.
Logged
93 Sidekick 2Dr.  2"body lift.  30" Tires. 1.5" Coil spacers. 4 door coils. 2"strut spacers. K&N Factory replacement filter. 2.25" Cat back, with glass pack.  Custom ground High torque Cam shaft. And CB for talkin trash.
*

Offline SunrunnerGT

  • 163
  • 0
  • Gender: Male
  • 1994 Pontiac Sunrunner GT and 1996 X90
    • Aaron's Suzuki
Re: Sagging Driver door, any tips on a fix?
« Reply #6 on: December 09, 2005, 01:52:07 PM »
i just had mine replaced with new ones. The weird thing is, that the top hinge was more money than the bottom one!? And they look the same gezzz ::)  The one was $45 and the other was $58. Oh and when i asked whats the diff no one could give me an answer ::)
Logged
Sunrunner GT, Gold Trim Level
Pages: [1]   Go Up
« previous next »